Magnum MPG 5600 Manual del operador Pagina 1

PORTABLE GENERATORMPG 5600OPERATING/PARTS MANUAL

GROUND SOURCELOCATIONGROUNDING THE GENERATORPREVENTION OF OVERLOADExceeding wattage capacity can result in damage to the generator and to the connecte

WATTAGE CONSUMPTION OF EQUIPMENTDEVICE APPROXIMATE RUNNING WATTSAir Conditioner (12,000 BTU)** ...

ADDING ENGINE OIL1. Place the generator on a firm, level surface.2. Remove the oil fill cap/dipstick. Clean the areaaround the oil fill cap and wipe

STARTING THE ENGINE1. Unplug all electrical loads from the unit’s receptacles before starting the engine.2. Make sure the generator is on a firm, leve

STOPPING THE ENGINE2. Turn the idle control switch off.3. Switch the main circuit breaker to the off position.3. Let the unit run for 3-5 minutes with

ITEM DAILY 20 HRS. 50 HRS. 100HRS. 300HRS. Check engine oil level  Change engine oil* Check air filter  Clean air filter  Replace air f

UNIT DECALSNote: All safety and operating decals shown above are located on decal sheet 26332, unless otherwise noted.16GROUND FAULT SENSING MODULEWAR

17ITEM NO. PART NO. QTY DESCRIPTION1 26213 1 Panel, control - rear housing2 24986R 1 Panel, control3 65888 2 Receptacle, 120V/20A duplex-black4 65878

18FRAME AND FUEL TANK ASSEMBLY11832214567682219343338379101113361335141310123433151617313219202023221934343029302228262741403989252442

ITEM NO. PART NO. QTY DESCRIPTION1 26123 1 Valve, fuel tank2 26122 1 Gauge, fuel tank3 28495 1 Cap, fuel tank4 28494 1 Tank, fuel5 60393 4 Screw, .250

2INTRODUCTIONThis manual provides information and procedures to safely operate and maintain the portable generator. For yourown safety and protection

TOMUFFLERTO FRAMETOFRAMETOFRAMEENGINE AND GENERATOR ASSEMBLY201213123451029127633391115161412171819824262518191924172320222117271918183029283132333435

21ITEM NO. PART NO. QTY DESCRIPTION1 60028 8 Screw, .312-18X1.000 hx hd2 60271 10 Washer, split lock .3123 61147 8 Nut, .312-18 U-clip G5 ZY long type

AC WIRING DIAGRAM221234(Y)(R)(B)(G)SEE DCPRINTWHT/BLKBLKCOMN/O1324LINELOADORN423COMMONS120 ONLY120/240XGWYGYWWXX867121011161415WXXGRN/YELWHTWHTWHTBLKY

ON/OFF SWITCHIDLE/RUN SWITCHIDLE/RUN MODULEGRNREDBLUORNIDLE/RUNSOLENOIDSHUTDOWNSOLENOIDCOILOIL LEVEL SWITCHOIL ALERT UNIT+ -CHARGE COILRECTIFIERSTART

REV: CPART NO: 2612702.04.09

3TABLE OF CONTENTSPageINTRODUCTION ...

4Note: Notes contain additional information important to a procedure and will be found within the regulartext body of this manual.OPERATING SAFETYBef

5ENGINE SAFETYInternal combustion engines present special hazards during operation and fueling! Failure to follow thesafety guidelines described belo

Unit ID Tag215 Power Drive • Berlin, WI 549231-800-926-9768MODELSERIAL NUMBERMPG 5600000000120/240 120/24041.7/20.846.7/23.3kglbs. amb. temp.rpm hz ph

7Read this manual carefully before attempting to use this generator. The potential for property damage, personalinjury or death exists if this equipm

FUEL TANK CAPFUEL LEVELGAUGEFUEL SHUTOFF VALVE(UNDER TANK)RECOILSTARTERCONTROL PANELENGINESTARTINGBATTERYBATTERY TRAY(OPTIONAL)ENGINEEXHAUSTWHEEL KIT(

GROUND FAULT SENSING MODULEWARNINGTEST BEFORE EACH USESEE INSTRUCTIONSRESETRESETPOWERFAULTABCDEFGH IMPG 5600CONTROL PANEL COMPONENTSA. ENGINE START SW